STUDY ON PROPERTY COMPARE OF NON-STYRENE AND STYRENE VINYL ESTER RESIN

Abstract

Abstract: Two kind of vinyl ester resin (VER) properties were tested under the same experimental conditions, including volatile organic compounds (VOC), mechanical properties, thermal properties, air dry and process performance. All the properties were compared. MFE 700-01 was non-styrene VER, while MFE 711 was styrene VER. The results show that VOC of MFE700-01 was lower, which can satisfy environment requirement, and the mechanical properties was same as the latter. Styrene VER can be replaced by non-styrene VER in most occasions.

Key words: non-styrene VER, environmental protection, VOC, FRP

CLC Number:

TB332

LIU Shi-qiang, MAO Ling-feng, ZHANG Wen-xuan, HUANG Zhi-chao. STUDY ON PROPERTY COMPARE OF NON-STYRENE AND STYRENE VINYL ESTER RESIN[J]. Fiber Reinforced Plastics/Composites, 2018, 0(5): 75-78.

References

[1] 周润培, 侯锐钢, 王晓东, 等. MFE乙烯基酯树脂及其在防腐蚀领域的应用研究(Ⅰ)[J]. 玻璃钢/复合材料, 2002(4): 35-37, 42.
[2] 邓睿, 周飞, 唐江, 等. VOC的排放以及控制措施和建议[J]. 材料导报, 2014, 28(s2): 378-384.
[3] 董永祺. 关于手糊工艺苯乙烯挥发的研究[J]. 建材工业信息, 1996(9): 14.
[4] 张衍, 陈锋, 刘力. 新型不饱和树脂苯乙烯挥发性能研究[J]. 玻璃钢/复合材料, 2010(6): 30-34.
[5] 刘华, 吕晓平, 茆凌峰, 等. 不饱和聚酯树脂低苯乙烯挥发助剂的研究与应用[J]. 热固性树脂, 2016, 31(6): 37-45.
[6] 刘华, 刘坐镇, 杭苏平, 等. 新型苯乙烯挥发抑制剂及低苯乙烯挥发树脂[J]. 热固性树脂, 2013, 28(3): 58-63.
[7] 厉娜. CCP公司推出ENCORE PRIMR无苯乙烯树脂[J]. 玻璃钢, 2013(2): 25.
[8] E. Can, J. J. La Scala, J. M. Sands, et al. The synthesis of 9-10 Dibromo stearic acid glycidyl methacrylate and its use in vinyl ester resins[J]. J. Appl. Polym. Sci., 2007, 106(6): 3833-3842.
[9] 朱强, 卢乃云, 李静. 苯乙烯挥发抑制剂的研究与应用[J]. 热固性树脂,1990(1): 29-32.
[10] Crawford Shaun, Lungu Claudiu T. Influence of temperature on styrene emission from a vinyl ester resin thermoset composite material[J]. Science of the Total Environment, 2011, 409(18): 3403-3408.
[11] 徐任信, 杨青海, 王钧, 等. 不同方法测得热固性树脂耐热性能的分析[J]. 国外建材科技, 2007(4): 12-14.
[12] Želimir Jelcˇic′, Franjo Ranogajec. Relaxation properties and glass transition by radiation crosslinking of unsaturated polyester resins[J]. Polimeri: Plastics and Rubber Journal, 2011, 31(3): 113-126.
[13] 肖红波, 王钧, 杨小利, 等. 树脂的粘度及表面张力对浸润速率影响研究[J]. 武汉理工大学学报, 2006(7): 15-17.
[14] 胶黏剂拉伸剪切强度的测定(刚性材料对刚性材料): GB/T 7124—2008[S].
[15] 李坤远, 杨汝平, 丁仁兴, 等. KH-550对环氧树脂胶黏剂粘接性能的影响[J]. 宇航材料工艺, 2013, 43(1): 86-88.